Paragraph Page
Motor, Oil Pan and Namplates . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.
. . . . . . . . . . . . . . . . . . . . . . 44
Oil Pump. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Camshaft, Valves and Timing Gear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.
..........................
Crankshaft, Flywheel . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.
.................
Fire Extinguisher. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
............
SPECIAL, TOOLS, TEST AND SUPPORT EQUIPMENT FOR ORGANIZATIONAL MAINTENANCE.
SECTION
IV.
(NOT APPLICABLE)
INDEX-FEDERAL
STOCK
NUMBER
AND REFERENCE NUMBER . . . . . . . . . . . . . . 83
INTRODUCTION
Explanation
Code
A
Assemblies which are not procured or stocked as such, but
This manual lists repair parts required for the per-
are made up of two or more units. Such component units
formance of organizational maintenance of the weld-
carry individual stock numbers and descriptions, are pro-
cured and stocked separately and can be assembled to form
ing machine.
the required assembly at indicated maintenance categories.
X
Parts and assemblies which are not preocured or stocked and
This repair parts and Special Tools list is divided into
the mortality of which normally is below that of the end
the following sections:
item or component. The failure of such part or assembly
should result in retirement of the end item from the supply
system.
A composite listing of the repair parts, special tools,
X1
Repair parts which are not procured or stocked. The require
test and support equipment having quantitative allow-
ment for such items will be filled by use of the next higher
ances for initial stockage at the organizational level.
assembly or component.
X2
b. Repair Parts-Section III. A
list of
repair parts
Repair parts which are not stocked. The indicated mainte-
nance category requiring such repair parts will attempt to
authorized for the performance of maintenance at the
obtain same through cannibalization. Where such repair
organizational level in figure and item number se-
parts are not obtainable through cannibalization, require
quence.
ments will be requisitioned, with accompanying justifica-
c. Special Tools, Test and Support Equipment-
tion, through normal supply channels
G
Section IV. A list of special tools, test and support
Major assemblies that are procured with PEMA funds for
initial issue only as exchange assemblies at DSU and GSU
equipment authorized for the performance of main-
level. These assemblies will not be stocked above DS and
tenance at the organizational level. (Not applicable. )
GS level or returned to depot supply level.
d. lndex-Federal Stock Number and Reference Num-
(2) Maintenance code indicates the lowest cate-
gory of maintenance authorized to install the listed
ascending numeric sequence followed by a list of
itern. Repair parts and special tools assigned mainte-
reference numbers in ascending alpha-numerical se-
nance code "C" may be stocked at the operator level of
quence, cross-referenced to the illustration figure
maintenance when authorized by the Unit Commander.
number and item number
The maintenance level codes are:
NOTE: Items not illustrated are cross-referenced
Explanation
Code
to page number.
C . . . . . . . . . . . . Crew or operator maintenance
3. Explanation of Columns
O . . . . . . . . . . Organizational maintenance
The following provides an explanation of columns in
(3) Recoverability code indicates whether un-
serviceable items should be returned for recovery or
a. Source, Maintenance, and Recoverability codes.
salvage. Items not coded are expendable. Recover-
(SMR).
ability codes are:
(1) Source code indicates the selection status and
Explanation
Code
source for the listed item. Source codes are:
R
Repair parts and assemblies which are economically repa-
Code
Explanation
rable at DSU and GSU activities and are normally furnished
P
Repair parts which are stocked in or supplied from the
by supply on an exchange basis.
GSA/DSA, or Army supply system and authorized for
S
Repair parts and assemblies which are economically repa-
use at indicated maintenance categories.
rable at DSU and GSU activities and which are normally
P2
Repair parts which are procured and stocked for insurance
furnished by supply on an exchange basis. When items are
purposes because the combat or military essentiality of the
determined by a GSV to be noneconomically reparable,
end item dictates that a minimum quantity be available in
they will be evacuated to a depot for evaluation and
the supply system.
analysis before final disposition.
M
Repair parts which are not procured or stocked, but are to
be manufactured in indicated maintenance levels.